双金属氢氧化物与改性海藻酸钠协同稳定液体石蜡/水乳液

doi:10.13218/j.cnki.csdc.2014.07.080

日用化学工业 ›› 2014, Vol. 44 ›› Issue (7): 361-365.doi: 10.13218/j.cnki.csdc.2014.07.080

• 基础研究 • 下一篇

双金属氢氧化物与改性海藻酸钠协同稳定液体石蜡/水乳液

刘若林¹, 李嘉诚¹, 颜慧琼¹, 李晓璇¹, 程春风¹, 林强²

1.海南大学材料与化工学院,海南海口 570228;
2.海南师范大学化学化工学院,海南海口 571158

收稿日期:2014-01-20 出版日期:2014-07-22 发布日期:2019-04-08
通讯作者: 林强,教授,博士生导师,电话:13807654689,E-mail:linqiang1962@gmail.com。
作者简介:刘若林(1987-),男,湖北黄冈人,硕士研究生,电话:13036000353,E-mail:ruolin0727@qq.com。
基金资助:
国家自然科学基金资助项目(21366010);"十二五"国家科技支撑计划资助项目(2011BAE06A06-7)

Liquid paraffin/water emulsion stabilized by synergistic action of bi-metal hydroxide and modified sodium alginate

LIU Ruo-lin¹, LI Jia-cheng¹, YAN Hui-qiong¹, LI Xiao-xuan¹, CHENG Chun-feng¹, LIN Qiang²

1.College of Materials and Chemical Engineering,Hainan University,Haikou,Hainan 570228,China;
2.College of Chemistry and Chemical Engineering,Hainan Normal University,Haikou,Hainan 571158,China

Received:2014-01-20 Online:2014-07-22 Published:2019-04-08

摘要/Abstract

摘要： 采用非稳态共沉淀法合成了Mg/Al双金属氢氧化物(LDH)。通过偶联酯化反应将疏水性的胆固醇(Chol)基接枝到海藻酸钠(Alg)上,制备了两亲性的改性海藻酸钠(Alg-Chol)。以Alg-Chol和LDH作为复合乳化剂,两者协同作用稳定液体石蜡/水乳液。采用傅里叶红外光谱(FTIR)、核磁共振氢谱(¹HNMR)、透射电镜(TEM)、激光粒度仪(DLS)、接触角测量仪和光学显微镜等,分别对LDH,Alg-Chol和LDH/Alg-Chol水分散体系以及液体石蜡/水乳液的性能进行了表征。TEM和DLS结果显示LDH的平均粒径为159 nm,分散系数(PDI)为0.267。FTIR和¹HNMR结果表明疏水性Chol基成功地接枝到Alg的侧链上。不同NaCl浓度下,LDH/Alg-Chol水分散体系在石蜡板上的接触角接近90°,说明LDH/Alg-Chol的润湿性较好,有利于增加乳液的稳定性。随着NaCl浓度的提高,乳液的粒径先由101.7 μm增大到121.8 μm,后来逐渐减小到58.1 μm。这是由于LDH/Alg-Chol在乳液液滴的表面自组装成为一层界面膜,并且LDH/Alg-Chol在油/水界面吸附量的变化影响乳液的粒径大小。

关键词: 改性海藻酸钠, 胆固醇, Mg/Al双金属氢氧化物, Pickering乳液

Abstract: Mg/Al bi-metal hydroxide (LDH) was prepared via unsteady co-precipitation method.Hydrophobic cholesterol (Chol) was grafted onto sodium alginate (Alg) via coupling esterification to form an amphiphilic modified sodium alginate (Alg-Chol).Then the Alg-Chol and LDH was blended to be an emulsifier for synergistic stabilization of liquid paraffin/water emulsion.The LDH,Alg-Chol,LDH/Alg-Chol water dispersion,as well as liquid paraffin/water emulsion were characterized by FTIR,¹HNMR,TEM,DLS,contact angle measurement and optical microscope et al.Results from TEM and DLS showed that the average size of LDH is 159 nm,and the dispersion coefficient is 0.267.Results from FTIR and ¹HNMR showed that the hydrophobic Chol group has been successfully grafted onto the side chain of Alg.With different NaCl concentration,the contact angle of LDH/Alg-Chol water dispersion system on paraffin plate is near to 90°,which denotes that the wetting power of LDH/Alg-Chol is quite high and is beneficial to upgrade the stability of the emulsion.As the concentration of NaCl increases,the particle size increases from 101.7 μm to 121.8 μm,then gradually drops to 58.1 μm.This is due to the LDH/Alg-Chol self-assembles to form an interface film on the surface of the liquid particles of the emulsion and the particle size of the emulsion is affected by the change of amount of LDH/Alg-Chol adsorbed on the oil/water interface.

Key words: modified sodium alginate, cholesterol, Mg/Al bi-metal hydroxide, Pickering emulsion

中图分类号:

TQ423

刘若林, 李嘉诚, 颜慧琼, 李晓璇, 程春风, 林强. 双金属氢氧化物与改性海藻酸钠协同稳定液体石蜡/水乳液[J]. 日用化学工业, 2014, 44(7): 361-365.

LIU Ruo-lin, LI Jia-cheng, YAN Hui-qiong, LI Xiao-xuan, CHENG Chun-feng, LIN Qiang. Liquid paraffin/water emulsion stabilized by synergistic action of bi-metal hydroxide and modified sodium alginate[J]. China Surfactant Detergent & Cosmetics, 2014, 44(7): 361-365.

参考文献

[1] RAMSDEN W.Separation of solids in the surface-layers of solutions and ‘suspensions’ (Observation on surface-membranes,bubbles,emulsions and mechanical coagulation):Preliminary account [J].Proceedings of the Royal Society of London,1903,72:156-164.
[2] PICKERING S.Emulsions [J].J Chem Soc,1907,91:2001-2021.
[3] WU C,TARIMALA S.Dynamics of charged microparticles at oil-water interface [J].Langmuir,2006,22:2112-2116.
[4] GOLEMANOV K,TCHOLAKOVA S.Latex-particle-stabilized emulsions of anti-bancroft type [J].Langmuir,2006,22:4968-4977.
[5] VOORN D J,MING W.Polymer-clay nanocomposite latex particles by inverse Pickering emulsion polymerization stabilized with hydrophobic montmorillonite platelets [J].Macromolecules,2006,39:2137-2143.
[6] MENON V B,WASAN D T.A review of the factors affecting the stability of solids-stabilized emulsions [J].Sep Sci Technol,1988,23:2131-2142.
[7] DICKINSON E. Emulsions and droplet size control [M]. Oxford:Butterworth-Heine-mann,1994:191-216.
[8] LAGALY G,REESE M S,ABEND S.Smectites as colloidal stabilizers of emulsions Ⅱ:Rheological properties of smectite-laden emulsions [J].Appl Clay Sci,1999,14:279-298.
[9] TAMBE D E,SHARMA M M.Factors controlling the stability of colloid stabilized emulsions I:An experimental investigation [J].J Colloid Interface Sci,1993,157:244-253.
[10] TAMBE D E,SHARMA M M.Factors controlling the stability of colloid stabilized emulsionsⅡ:A model for the rheological properties of colloid-laden interface [J].J Colloid Interface Sci,1994,162:1-10.
[11] ABEND S,BONNKE N.Stabilization of emulsions by heterocoagulation of clay minerals and layered double hydroxide [J].Colloid Polym Sci,1998,276:730-737.
[12] LIU SHANGYING, ZHANG JIE, WANG NING, et al. Liquid-crystalline phases of colloidal dispersions of layered double hydroxides [J].Chem Mater,2003,15:3240-3241.
[13] DUAN HONGWEI, WANG DAYANG, KURTH G DIRK,et al.Directing self assembly of nanoparticles at water/oil interfaces [J].Angew Chem Int Ed,2004,43:5639-5642.

[1]	丁正青, 吴颖异, 王维运, 黄旭娟, 蔡照胜. 羟乙基纤维素/纳米纤维素稳定的Pickering乳液及其流变特性研究[J]. 日用化学工业（中英文）, 2023, 53(3): 245-252.
[2]	陈宁茹, 张若淇, 韩旭, 尚亚卓. 新型乳化体系及其在化妆品中的应用（Ⅲ）——Pickering乳液[J]. 日用化学工业（中英文）, 2023, 53(11): 1257-1265.
[3]	沈嘉骏,宦静静,王碧佳,隋晓锋. 纳米甲壳素稳定蜂蜡油凝胶Pickering乳液的性能研究[J]. 日用化学工业, 2022, 52(8): 844-850.
[4]	张倩洁,沈兴亮,盛涛涛,张婉萍,许建营. 十六烷基三甲基溴化铵-珍珠粉相互作用及其稳定乳液的双重相转变[J]. 日用化学工业, 2022, 52(5): 468-475.
[5]	谢鑫,王伟浩,刘环宇,孙梦梦,李沁园,贾露凡,孟涛. Alg@TiO₂微球稳定的Pickering乳液用做防晒乳成分的研究[J]. 日用化学工业, 2022, 52(3): 229-236.
[6]	陈云博,李昕怡,毛志平,徐红,隋晓锋. 纳米甲壳素基Pickering乳液辅助构筑相变微胶囊[J]. 日用化学工业（中英文）, 2022, 52(12): 1286-1292.
[7]	宦静静,王碧佳,毛志平,隋晓锋. 纳米甲壳素的快速制备及其乳化性能研究[J]. 日用化学工业（中英文）, 2022, 52(10): 1081-1087.
[8]	沈永强,孙亚娟,杨成,王靖. 桃仁分离蛋白颗粒的制备及其乳化性能研究[J]. 日用化学工业, 2021, 51(9): 809-816.
[9]	于惠,朱永峰,惠爱平,杨芳芳,王爱勤. 凹凸棒石在Pickering乳液制备中的应用研究进展[J]. 日用化学工业, 2021, 51(7): 670-678.
[10]	龚成易,于浩,王琦琦,孙继勇,宋爱新. 刺激响应性Pickering乳液及其应用研究进展[J]. 日用化学工业, 2021, 51(6): 554-563.
[11]	方振兴,王希英,吴婧,曾颖,潘虹,谢振华. 火山矿泥Pickering乳液的制备及其pH稳定性[J]. 日用化学工业, 2021, 51(6): 506-512.
[12]	何怡静,许虎君. 月桂酰基赖氨酸稳定的Pickering乳液的制备研究[J]. 日用化学工业, 2021, 51(5): 413-420.
[13]	胡佳雯,樊晔,方云,王红. CLAA@CaCO₃纳米颗粒稳定双水相Pickering乳液[J]. 日用化学工业, 2021, 51(12): 1186-1191.
[14]	张倩洁,沈兴亮,张婉萍. 超细珍珠粉制备Pickering乳液的影响因素研究[J]. 日用化学工业, 2021, 51(1): 1-9.
[15]	喻明英,王靖,杨成,曹光群. Pickering乳液聚合法制备复合防晒微球体[J]. 日用化学工业, 2021, 51(1): 38-43.

双金属氢氧化物与改性海藻酸钠协同稳定液体石蜡/水乳液

Liquid paraffin/water emulsion stabilized by synergistic action of bi-metal hydroxide and modified sodium alginate

PDF (PC)

赞

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 15

Metrics

本文评价

推荐阅读 10