气相色谱法测定化妆品用原料聚乙烯醇中甲醇含量

doi:10.13218/j.cnki.csdc.2018.06.010

摘要/Abstract

摘要： 建立了气相色谱法测定化妆品用原料聚乙烯醇(固体)中甲醇含量的方法。研究发现顶空法较蒸馏法、直接稀释法更适合用于测定化妆品用原料聚乙烯醇中甲醇含量。分别考察了溶剂和盐析剂对测定结果的影响,发现最佳的溶剂和盐析剂分别为10 mL水和0.5 g氯化钠。结果表明甲醇质量浓度在10~1 000 mg/L范围内线性关系良好,相关系数可达0.999 5,其回收率为92.6%~104.8%,相对标准偏差在1.2%~6.5%之间,检出限为5 mg/L。实验结果证明,该方法适用于化妆品用原料聚乙烯醇中甲醇含量的检测。

关键词: 化妆品原料, 聚乙烯醇, 顶空气相色谱, 甲醇

Abstract: A gas chromatography method was established for the determination of methanol in polyvinyl alcohol used in cosmetics.It is found that headspace method is more suitable than distillation method and direct dilution method to determine the methanol in polyvinyl alcohol used in cosmetics.The factors of solvent and salting-out agent were investigated and the appropriate conditions are 10 mL water and 0.5 g sodium chloride,respectively.Results indicate that the linear relationship of methanol in the range of 10-1 000 mg/L is good,with correlation coefficient of 0.999 5.The recoveries are ranged from 92.6% to 104.8%,while the relative standard deviations are ranged from 1.2% to 6.5% and the detection limit is 5 mg/L.The results prove that this method is suitable for the determination of methanol in polyvinyl alcohol used in cosmetics.

Key words: cosmetic ingredients, polyvinyl alcohol, headspace gas chromatography, methanol

中图分类号:

TQ658

杨铭, 张丽华, 胡丹, 王晨蕾, 任承方. 气相色谱法测定化妆品用原料聚乙烯醇中甲醇含量[J]. 日用化学工业, 2018, 48(6): 352-355.

YANG Ming, ZHANG Li-hua, HU Dan, WANG Chen-lei, REN Cheng-fang. Determination of methanol in polyvinyl alcohol used in cosmetics by gas chromatography[J]. China Surfactant Detergent & Cosmetics, 2018, 48(6): 352-355.

参考文献

[1] Jia M F,Li X,Wang S.Production situation and market prospect of polyvinyl alcohol [J].Yunnan Chemical Technology,2012,39(5):36-40.
[2] Lei C T,Pan X Y,Yao G H,et a1.Progress in water-soluble polyvinyl alcohol [J].China Plastics Industry,2011,39(2):10-13.
[3] Wang T H,Yang F,Yu F Q,et a1.Analysis and prospect of polyvinyl alcohol (PVA) [J].Shandong Chemical Industry,2016,45(2):49.
[4] Xu F H,Yang B X,Cheng G X.Progress in new usage of polyvinyl alcohol [J].Chemical Industry and Engineering Progress,2001(9):39-42.
[5] Liu Y F,Zhang J L.Advances in detection methods of methanol in cosmetics [J].Detergent & Cosmetics,2015,38(5):36-43.
[6] Wang M L,Wang J T,Chong Y M.A rapid and accurate method for
determination in alcoholic beverage by direct injection capillary gas chromatography [J].J Food Composition and Analysis,2004,17(2):187-196.
[7] Su Y H,Liu W J.The research of determination of methanol used in industry [J].Shandong Chemical Industry,2016,45(8):53-54.
[8] Guo H,Zhang W G,Wang S S.Determination of methanol in cosmetics by gas chromatography and its variance evaluation [J].Chinese Journal of Public Health Engineering,2012,6(11):242-246.
[9] Yan J L.Determination of methanol in cosmetics by gas chromatography [J].Analytical Chemistry,1989,17(10):957.
[10] Li J R,Ma Q,Ma H J,et al.Determination of free methanol content in cosmetics by GC-FID [J].Chinese Journal of Health Laboratory Technology,2014,24(6):776-778.
[11] Zhu W H,Lu S M,Zhu L,et al.Determination of methanol in food additives by headspace-gas chromatography/mass spectrometry method [J].Flavour Fragrance Cosmetics,2013(2):21-24.
[12] Chen W S,Qi Z C,Chen B Y,et al. Determination of methanol in cosmetics by sulfurous acid and basic fuchsine colorimetry [J]. Journal of Environment and Health,2004,21(1):58-59.
[13] Wang M X.Study on colorimetric fuchsin sulfurous acid methanol content in the toilet water [J].Journal of Guangdong Polytechnic Normal University,2014(7):71-73.
[14] J M Garrigues,A Perez-Ponce,M De la Guardia,et al.Direct determination of ethanol and methanol in liquid samples by means of vapor phase Fourier transform infrared spectrometry [J].Vibrational Spectroscopy,1997,15:219-228.
[15] A Perez-Ponce,F J Rambla,M De 1a Guardia,et al.Partial least-squares-Fourier transform infrared spectrometry determination of methanol and ethanol by vapor-phase generation [J].Analyst,1998,123(6):1253-1258.